Peugeot Forums banner

1 - 20 of 43 Posts

·
Registered
Joined
·
33 Posts
Discussion Starter #1
:mad:ok changed and upgraded engine mounts all suspention joints fine and still judders when you take up drive (clutch judder) ??? its been doing it for 2 years now is it the clutch and is there any tests I can do also any1 know how much for a clutch replacement its a 03 1.9 110 hdi ????
 

·
Registered
Joined
·
1,860 Posts
Hi

You have done the left hand mount ?

Have you checked inner track rods ?

Is your right hand drive shaft ok ?

Mine is the 06 model same clutch judder on take off I am getting much more sorted about 65% better so far still got parts being delivered 90% sure it's not clutch yet

Pug clutch flywheel £1100 Mr Clutch £900 parts only about £360

Good luck


Sent from AutoGuide.com App
 

·
Registered
Joined
·
4,778 Posts
:mad:ok changed and upgraded engine mounts all suspention joints fine and still judders when you take up drive (clutch judder) ??? its been doing it for 2 years now is it the clutch and is there any tests I can do also any1 know how much for a clutch replacement its a 03 1.9 110 hdi ????
could be dual mass flywheel on last legs i put a solid mass conversion kit on mine and it sorted the judder and feels great
 

·
Registered
Joined
·
33 Posts
Discussion Starter #4
hi border all yes I upgraded the lower rear mount did make it feel better for a week but now bad again inner tie rods fine driveshafts feel ok not to much play and no clicking on full lock just seems like the engine wants to shake itself when u half release the clutch pedal been like it 2 years now but getting worse ?? and I understand a clutch aint cheap :eek:
 

·
Registered
Joined
·
33 Posts
Discussion Starter #8
Hi

I note you say lower mount is that the one near the gearbox / shaft

I mean the one under the battery box mine was split.

Hope neither of us needs a clutch I agree eek


Sent from AutoGuide.com App
no I got a upgrade mount its the 1 at the rear of the engine with the driverside driveshaft running through it maybe I should just buy the other 2 mounts and replace those ???? what you think its so strange as the clutch bites good doesent slip and isent high or low on the pedal just seems to judder on take up ok between gears just when its under major load eg pulling off from stand still and its been like it 2 years now ??
 

·
Registered
Joined
·
1,860 Posts
Hi

I bought mine at ecp last week it was £17 on offer this week about £12 as I say mine had a split and made a big difference on my car. I have ordered the powerflex bottom mount should have it soon my fingers are crossed. I don't think it's the dmf hope I am right.

For such a low cost and less than an hours work I would do the one under the battery for sure


Sent from AutoGuide.com App
 
C

·
Guest
Joined
·
0 Posts
Hi Guys when I had my 2.0 tdci Mondy I took her to a garage who specialises mostly in clutches even though he hates doing them :lol: Long story basically he worked for a garage that I trust as their clutch guy branched out on his own now all they do is recommend him for clutches ha! Anyway he put mine into 3rd gear and lifted it up to the biting point saying that if it was the DMF you would feel the Peddle banging against your foot don't know how accurate of a test this is but he turned me away for a clutch and set to work diagnosing the actual problem
 

·
Registered
Joined
·
33 Posts
Discussion Starter #13
Hi

I bought mine at ecp last week it was £17 on offer this week about £12 as I say mine had a split and made a big difference on my car. I have ordered the powerflex bottom mount should have it soon my fingers are crossed. I don't think it's the dmf hope I am right.

For such a low cost and less than an hours work I would do the one under the battery for sure


Sent from AutoGuide.com App
yer worth me doing it just to rule it out do you have a link to the mount and is yours the 1.9 hdi 110bhp mine is a 03 plate ?
 

·
Registered
Joined
·
33 Posts
Discussion Starter #16
Hi mines the 1.6 110 bhp 2006 so probably a different mount never knew they did a 1.9 assume it will still have a mount at gearbox side though


Sent from AutoGuide.com App
it says 1997cc on the paperwork is it 1.9 or 2.0ltr ? lol:confused: and thanks for the link I found the mount on ebay £9.95 will do it cheers then update the progress
 

·
Registered
Joined
·
33 Posts
Discussion Starter #20
Hi Guys when I had my 2.0 tdci Mondy I took her to a garage who specialises mostly in clutches even though he hates doing them :lol: Long story basically he worked for a garage that I trust as their clutch guy branched out on his own now all they do is recommend him for clutches ha! Anyway he put mine into 3rd gear and lifted it up to the biting point saying that if it was the DMF you would feel the Peddle banging against your foot don't know how accurate of a test this is but he turned me away for a clutch and set to work diagnosing the actual problem
keep us up to date if you find the fault and thanks for the info I go try it
 
1 - 20 of 43 Posts
Top