Climate Control Problem on 307 - Peugeot Forums
Peugeot Forums - Peueot - Citroen Community
Home :: Peugeot Forums :: Rules :: Articles :: About Us :: Partner Vendors :: Advertise


Go Back   Peugeot Forums > Peugeot Models > 307
PeugeotForums.com is the premier Peugeot All Forum on the internet. Registered Users do not see the above ads.
Reply
 
LinkBack Thread Tools Display Modes
Old 25-05-17, 08:59 PM   #1
Inactive User
 
Join Date: May 2017
Posts: 29
Default Climate Control Problem on 307

Hi Group

Newbie here so please go easy one me, I have posted an introduction !. Long time Peugeot owner who has just acquired a 307 1.6 HDi 2004 with 82k on the clock.

I have always had models with basic air conditioning systems fitted but this has an automatic air con/ climate control system. I have looked through this site and found information on basic systems and duel zone automatic systems, however nothing on the system mine has fitted. It appears that, unsurprisingly, it is a generic Peugeot unit fitted to many cars until about 2005.

The control unit in the car looks like

climate-control-307-image-1.jpg

climate-control-307-image-2.jpg


The problem I have is that on occasions, and especially if the car has been standing in warm weather, the climate control system works for a period of time and then switches off. The display stays on as normal with no error message displayed but the fans don't turn on no matter what speed I select, also the flaps do not move. Running the system in manual or auto mode, or having A/C or Eco selected has no effect. After a period of time the system fires up again and runs for another short period until once more it shuts down. The cycle repeats its self for the whole of my journey.

It is as if the system shuts down completely leaving me with no ventilation. At the present time it is not to much hassle, as I open a window. I want to get the system sorted as I don't know what will happen in winter and this will leave me with no demisters. When it runs everything works heater control/direction control and A/C on and off.

As I am not very technical minded I do not want to get ripped off by local garages or air con specialists. If anyone knows of a reputable specialist who is good at diagnosing these problems in the Shropshire/Staffordshire or West Midlands area please let me know.

I have posted this in general discussion as the problem may occur with other models with the same unit fitted.

If you have read this far, thanks for your attention.

Many Thanks in anticipation.
Dave
DJ Wmid is offline   Reply With Quote Quick reply to this message
Sponsored Links
Advertisement
 
Old 25-05-17, 09:11 PM   #2
Senior Member
 
Join Date: Oct 2012
Location: falkirk
Posts: 14,010
Default

Most likely wiring problems on the fan itself its a common issue the contacts heat up it stops working they cool down you hit a bump whatever and they connect again for a while then repeats
__________________
assume nothing check everything twice !!
reliable406 is offline   Reply With Quote Quick reply to this message
Old 25-05-17, 10:24 PM   #3
Senior Member
 
Join Date: Sep 2016
Location: New Zealand
Posts: 1,134
Default

Check this post on info to access/remove motor.. https://www.peugeotforums.com/forums/...cation-264018/
WillNZ is offline   Reply With Quote Quick reply to this message
 
Old 26-05-17, 07:40 AM   #4
Inactive User
 
Join Date: May 2017
Posts: 29
Default

Thanks both for your prompt response. Sorry to ask a stupid question but will I need to change the heater motor, the wiring harness or both.

I have looked on line for replacement motors and harnesses and there is conflicting information about fitment. Do I have to take the old motor out to find the original part number for the motor and harness or are they a standard fitment.

Is it a very hard job to take the old one out just to find the part number, I am not very technically minded but am ok with a screwdriver.

Thanks again guys for the advice.
DJ Wmid is offline   Reply With Quote Quick reply to this message
Old 26-05-17, 09:01 PM   #5
Moderator
 
windy1603's Avatar
 
Join Date: Sep 2012
Location: Hertfordshire
Posts: 5,500
Default

When was pollen filter last changed, if its blocked it will overwork then fan and speed controller will overheat and shut fan off. I would look at a faulty speed controller on fan next
__________________
DS5 & DS4 DSport 2.0 HDI 2012, 107 1.0 Urban 2006, 208 1.6 e-HDI Feline 2014, Suzuki RGV 250M 1989 (Money Pit)
windy1603 is offline   Reply With Quote Quick reply to this message
Old 27-05-17, 09:55 PM   #6
Inactive User
 
Join Date: May 2017
Posts: 29
Default

Hi Windy, thanks for the advice. I changed the pollen filter when I acquired the car last week. I didn't think the system I have installed has the speed controller that gives a lot of grief. Sorry to be a pain but where would I find it, or does it form part of the motor.

Thanks Again
DJ Wmid is offline   Reply With Quote Quick reply to this message
Sponsored Links
Advertisement
 
Reply

Quick Reply
Message:
Options

Register Now

In order to be able to post messages on the Peugeot Forums forums, you must first register.
Please enter your desired user name, your email address and other required details in the form below.
User Name:
Password
Please enter a password for your user account. Note that passwords are case-sensitive.
Password:
Confirm Password:
Email Address
Please enter a valid email address for yourself.
Email Address:

Log-in


Thread Tools
Display Modes

Posting Rules
You may post new threads
You may post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are On
Pingbacks are On
Refbacks are On



All times are GMT. The time now is 12:39 AM.



Powered by vBulletin® Copyright ©2000 - 2019, vBulletin Solutions, Inc.
Content Relevant URLs by vBSEO 3.6.0
vBulletin Security provided by vBSecurity v2.2.2 (Pro) - vBulletin Mods & Addons Copyright © 2019 DragonByte Technologies Ltd.